Condo terraces, school courtyards, splash pads, seniors' residences, daycare yards and horse barns from the harbour to the farms north of Brooklin all fall under commercial and equestrian rubber surfacing, and each one is measured and quoted in writing. Every Whitby job we take is fully insured, start to finish.
We pour rubber surfacing in wash stalls, barn aisles and grooming bays so a wet, shod horse stands on grip instead of on slick concrete. Up on the moraine around Ashburn and Myrtle the horse farms sit on sand that drains well, but a concrete aisle inside the barn is still hard, cold and slippery when hosed. Rubber mats shift, curl and trap urine at the seams.
Poured rubber surfacing is seamless, drains, is warm underfoot, and is kinder to legs and hooves than concrete. Rubber surfacing is also easier to keep clean, which matters in a wash stall used every day.
Rooftop terraces, balconies, courtyards and splash pads get rubber surfacing from Whitby Rubber Surfacing where water has to get off the surface fast and noise has to stay off the units below. The condo buildings going up around Whitby Harbour and along Victoria Street have terraces over living space, and a hard paver terrace over a membrane is both loud and a puddle problem in a freeze-thaw winter.
A school courtyard in Pringle Creek or a daycare yard in Williamsburg gets the same rubber surfacing in colour, with the thickness set by what the children will be doing on it. A seniors' residence courtyard gets rubber surfacing for the grip and the soft landing.
We visit the site, tape the area, inspect the base, note the drains and edges, and confirm access for the mixer. Existing concrete, asphalt, pavers or membrane-protected decks are cleaned, repaired and primed. On a farm the aisle is scrubbed and dried before priming.
Mixed on the spot, the rubber surfacing gets spread by trowel to the depth on the quote, in black SBR for barns and back-of-house areas and in coloured EPDM where the surface shows. Edges at doors, drains and thresholds are protected. A barn aisle can take horses after two to three days.
Arrange a free visit and Whitby Rubber Surfacing will tape the area and write a quote that sets out product, depth, square feet and cost. Commercial rubber surfacing around here usually costs $8 to $16 a square foot on top of what is already down, and more wherever it is poured thick. A play structure in the same yard gets priced through our playground rubber surfacing service. What else we pour is under rubber surfacing services, or contact us to fix a visit date.
The other surfaces we pour are listed here, each with its own page.
Around an in-ground pool, the concrete, pavers or stamped deck already in place becomes the base, and we trowel pool deck rubber surfacing onto it for a cooler, softer, slip-resistant finish. Every Whitby job we take is fully insured, start to finish.
View Pool Deck Surfacing
Salt-pitted garage floors and cracked drives, concrete or asphalt, get covered by our driveway and garage rubber surfacing, a skin that sheds water and will not scale. Every Whitby job we take is fully insured, start to finish. Whatever slab is down now is what the rubber surfacing gets poured onto.
View Driveway and Garage Floor Surfacing
Backyards, daycares, schools, churches and parks get playground rubber surfacing from us: a deep cushion layer matched to the equipment under a coloured top. Every Whitby job we take is fully insured, start to finish. The finished playground is seamless, drains, and can be crossed in a wheelchair.
View Playground Safety Surfacing
Paths and steps in concrete, interlock, stone or wood get wrapped by our patio and step rubber surfacing in one continuous skin that sheds water and holds a boot through ice season. Every Whitby job we take is fully insured, start to finish. Whatever is down now stays put as the base.
View Patio, Walkway and Step Surfacing
Home gyms, fitness studios, school weight rooms and arena dry-land areas get seamless gym rubber surfacing from us, glued down to the slab so it can never creep apart the way mats do. Every Whitby job we take is fully insured, start to finish. Black SBR is the standard, with colour if the room wants it.
View Gym and Fitness FlooringWe tape the area on a free site visit and leave a written price. Call +1 289-307-8672, or fill in the form.
Describe the surface, its rough size and its condition, and we will phone to set up a free site visit. A name and a number are enough to send it. Phoning is fine too, and the number is +1 289-307-8672.
